吊车的使用和操作

CSPC Nanhai Petrochemicals Project/CSPC 南海石化项目 Bechtel – SEI – Foster Wheeler PMC/项目管理承包商

ATTACHMENT A (Form 8710-0000-0009-A-Rev 02)

附件A （表8710-0000-A-02版）

DAILY RT AND HYDRAULIC TRUCK CRANE CHECKLIST 复杂地形起重机和液压汽车吊日检表

DATE ____________________ S/N ______________________ S/N ______________________

EQUIPMENT NUMBER __________________ MAKE ________________________________ ENGINE ______________________________

MODEL ____________________ MODEL ____________________

HOURMETER UPPER _______________________________ HOURMETER LOWER _______________________________

(S) INSPECTED AND SATISFACTORY

KMS. _________________________

(X) REQUIRES RECHECK AND/OR REPAIR

(N/A) NOT APPLICABLE

(R) REPAIRED AND/OR ADJUSTED N/A BOOM ASSEMBLY BOOM WEAR PADS BOOM EXTENSION POINT SHEAVES BOOM EXTEND CYL BOOM HOIST CYL JIB HYDRAULIC ASSEMBLY HYDRAULIC LINES UPPER HYDRAULIC LINES LOWER OUTRIGGERNEXTEND CYLS OUTRIGGERJACK CYLS HOLDING VALVES BOOM S R X S

R X

N/A

CONTROLS BOOM UP-DOWN BOOM EXTEND-RETRACT 1 HOISTS 2 HOIST AUX 3 HOIST AUX SWING TRAVEL OUTRIGGERS STEERING BRAKES HOUSE LOCK S R X N/A HOLDING VALVES OUTRIGGERS STEERING CYLS HYDRAULIC PUMPS HYD. HOIST MOTORS OTHERS ENGINE UPPER RADIATOR COOLING SYSTEM OIL PRESSURE EXHAUST SYSTEM CONVERTOR / CLUTCH HOISTS 1 AUX. HOIST ASSEMBLY 2 AUX. HOIST ASSEMBLY 3 AUX. HOIST ASSEMBLY MAIN HOIST ASSEMBLY SWING SWING LOCK PIN SWING FUNCTION RING GEAR SWING BRAKES BELTS ENGINE LOWER RADIATOR COOLING SYSTEM OIL PRESSURE EXHAUST SYSTEM CONVERTOR / CLUTCH BELTS ELECTRICAL UPPER GAUGES BATTERY WARNING SYSTEM CHARGING SYSTEM ELECTRICAL LOWER GAUGES BATTERY WARNING SYSTEM SWING PINION DRIVE TRAIN FRONT AXLE REAR AXLE’S HI/LO RANGE TRANS. TRANSMISSIONS CONVERTORS CLUTCH DRIVE LINES FOUR/SOX-WHEEL DRIVE LUBRICATION CHECK ENGINE OIL LEVELS CHASSIS DRIVE TRAIN BOOM ASSEMBLY RING GEAR BOOM PINS LINKAGE OTHER TRANSMISSIONS FINAL DRIVE OUTRIGGER ASSEMBLY CHARGINE SYSTEM AIR SYSTEM BRAKES CONTROLS COMPRESSOR MAXI BRAKES SYSTEM ATTACHMENTS HEADACHE BALL LOAD BLOCK ROOSTER SHEAVE OTHER SAFETY ITEMS LOAD CHART FIRE EXTINGUISHER HAND SINGAL CHECK WARNING SIGNALS HORN BACKUP ALARM SPILL KITS (AVAILABLE) LOAD MOMENT INDICATOR ANTI-TWO BLOCK LOAD LINES MAIN LOAD LINE 1 AUX LOAD LINE 2 AUX LOAD LINE 3 AUX LOAD LINE MANUALS PARTS MANUAL

SERVICE MANUAL S.L.I. MANUAL OPER. HANDBOOK ENGINE MANUAL

TIRES

FRONT PERCENTAGE WEAR LIFE LEFT

BODY SHEET METAL GLASS

PAINT FRAME

SIZE ______________________

OPERATOR COMMENTS:

TYPE __________________________PLY

PR-8710-0000-0009, Rev. 03

Cranes Use and Operation吊车的使用和操作

Page 21 of 30

CSPC Nanhai Petrochemicals Project/CSPC 南海石化项目 Bechtel – SEI – Foster Wheeler PMC/项目管理承包商

ATTACHMENT B (Form 8710-0000-0009-A-Rev 02)

附件B （表8710-0000-A-02版）

DAILY CRAWLER CRANE CHECKLIST 履带吊日检表

DATE ____________________ S/N ______________________

EQUIPMENT NUMBER __________________ MAKE ________________________________

MODEL ____________________

HOURMETER UPPER _______________________________ HOURMETER LOWER _______________________________

(S) INSPECTED AND SATISFACTORY

(R) REPAIRED AND/OR ADJUSTED N/A INDEPENDENT SWING SWING FUNCTION CONTROLS CLUTCHES BRATES HOUSE LOCK HYDRAULIC MOTOR AIR CYLINDERS AIR LEAKS HYDRAULIC HYDRAULIC MOTORS LUBRICATION ADJUSTMENTS (X) REQUIRES RECHECK AND/OR REPAIR (N/A) NOT APPLICABLE

UNDERCARRIGE LUBRICATION TRACK ADJ. OTHER S R X S R X N/A BOOM HOIST PUMP / MOTOR BRAKE CLUTCHES PAWL CUT OFF SETTING AUZILIARY BUTT POINT SECTION JIB LACINGS SHEAVES EQUALIZER BOOM STOP SPREADER BAR EQUALIZER ROOSTER GANTRY TOWER ATTACHMENT MAST LUFFING ATTACHMENT S R X N/A TURN TABLE HOUSE ROLLERS/ROTEC HOOK ROOLERS ROLLER PATH LUBRICATION BOOM ASSEMBLY ENGINE UPPER ENGINE SHUT DOWN THROTTLE CONTROL OIL PUMPS / MOTORS ENGINE CONDITION COOLING SYSTEM RADIATOR BATTERY LUBRICATION CONVERTERS MAIN DRIVE SHAFT TRAVEL FUNCTION HYDRAULIC MOTOR CLUTCHES TRAVEL TRAVEL STEER RIGHT STEER LEFT HYDRAULIC AIR CYLINDERS OIL LUBRICATION ADJUSTMENTS OTHER ENGINE LOWER ENGINE SHUT DOWN THROTTLE CONTROL OIL PUMPS / MOTORS ENGINE CONDITION COOLING SYSTEM RADIATOR BATTERY LUBRICATION CONVERTERS ATTACHMENTS HEADCHE LOAD BLOCK OTHER WIRE ROPE PENDANT LINES BOOM HOIST LOAD CABLE WHIP CABLE LEFT DRUM / REAR DRUM BRAKES CLUTCHES HYDRAULIC AIR CYLINDERS OIL LUBRICATION ADJUSTMENTS OTHER HYDRAULIC MOTOR OTHER SAFETY ITEMS AND BODY SHEET METAL GLASS PAINT SEAT FRAME COMPUTER MANUAL OPERATORS LOAD CHARTS HAND SIGNAL CHART WARNING DECALS FIRE EXTINGUISHER SPILL KIT ANTI-TWO BLOCK BOOM ANGLE LIMIT SWITCH CAB CONTROL SAFETY WARNING LOAD MOMENT INDICATOR DRUM ROTATION INDICATION AIR GAUGES BOOM CONTROL SWING HOUSE LOCK HOIST MAN THIRD DRUM WHIPLINE / AUX DRUM LOCKS TRAVEL BOOM PAUL SWING CONTROL DRUM PAWL RIGHT DRUM / FRONT DRUM BRAKES CLUTCHES HYDRAULIC MOTOR DRUM PAWL HYDRAULIC AIR CYLINDERS OIL LUBRICATION ADJUSTMENTS PR-8710-0000-0009, Rev. 03

Cranes Use and Operation吊车的使用和操作

Page 22 of 30

CSPC Nanhai Petrochemicals Project/CSPC 南海石化项目 Bechtel – SEI – Foster Wheeler PMC/项目管理承包商

ATTACHMENT C (Form 8710-0000-0009-A-Rev 02)

附件C （表8710-0000-A-02版）

INSPECTION REPORT CRAWLER CRANE 履带吊检查报告

DATE ____________________ S/N ______________________ S/N ______________________ COP#_____________________

EQUIPMENT NUMBER __________________ MAKE ________________________________ ENGINE ______________________________ HOURMETER _______________________________

TRACKS TRACK ADJ. DRIVE CHAINS, ROLLERS IDLERS SPROCKETS TRACK GUIDES TRAVEL LOCKS TRAVEL CLUTCHES STEERING CLUTCH L. STEERING CLUTCH R. HOUSE ROLLERS HOOK ROLLERS TRAVEL PINION TRAVEL GEAR ROLLER PATH CAR BODY (S) INSPECTED AND SATISFACTORY

MODEL ____________________ MODEL ____________________

(R) REPAIRED AND/OR ADJUSTED (X) REQUIRES RECHECK AND/OR REPAIR

UNDER CARRIAGE S R X INDEPENDENT SWING ASSEMBLY BEVEL GEAR PINION GEARS SHAFT BEARINGS RIGHT CLUTCH LEFT CLUTCH AIR CYLINDERS SWING BRAKE RIGHT PRESSURE PLATE LEFT PRESSURE PLATE S R X BOOM ASSEMBLY (Cont’d) BOOM STOP PENDANT LINES MAST SPREADER BAR TOWER ATTACHMENT S R X RINGER ASSEMBLY LUBRICATION CHECK CHAIN CASE BOOM HOIST OIL SUMP BEVEL GEARS OPEN GEARS ENGINE OIL CONVERTOR OIL SPRAG OIL FRONT CONV. CONDITION MAIN DRIVE SHAFT ASSEMBLY BEVEL GEAR PINION GEARS SHAFT BEARINGS RIGHT CLUTCH LEFT CLUTCH AIR CYLINDER RIGHT PRESSURE PLATE LEFT PRESSURE PLATE ENGINE INJECTOR FUEL PUMP COMPRESSION CHECK FUEL FILTER OIL FILTER CONVERTOR FILTER CONVERTOR OIL ENGINE CONDITION RADIATOR REAR CONV. CONDITION SAFETY ITEMS AND WIRE ROPE BOOM HOIST CABLE LOAD CABLE WHIP CABLE SPRAG CLUTCH PILOT AIR VALVE LOAD MOMENT INDICATOR ANTI-TWO BLOCK BOOM ANGLE LIMT SWITCH LOAD CHARTS FIRE EXTINGUISHER HAND SIGNAL CHART WARNING DECALS LEFT DRUM ASSEMBLY DRUM GEAR DRUM SHAFT CLUTCH LINING AIR CYLINDERS DRUM BEARINGS BATTERY NEW CAB CONTROL SWING VALVE HOIST VALVE WHIP LINE VALVE STEERING VALVE SPRAG VALVE TRAVEL VALVE BRAKE LINING RIGHT DRUM ASSEMBLY DRUM GEAR DRUM SHAFT CLUTCH LINING BRAKE LINING AIR CYLINDERS DRUM BEARINGS OPERATION TRAVEL CUT LEFT CUT RIGHT TRAVEL LOCKS SWING BOOM HOIST LOAD WHIP AIR GAUGES BOOM HOIST ASSEMBLY BRAKE LEFT CLUTCH RIGHT CLUTCH SPRAG PILOT-AIR VALVE BEVEL GEAR PINION GEARS OIL SEALS BOOM ASSEMBLY BUTT POINT SECTION JIB LACINGS SHEAVES HEADACHE BALL (INTL ORANGE) EQUALIZER SHEAVES LOAD BLOCK (INTL ORANGE) LOAD CHART PARTS MANUAL SERVICE MANUAL BODY SHEET METAL GLASS PAINT SEAT FRAME GENERAL BOOM & JIB INVENTORY

MANUALS: APARTS SERVICE OPERATORS COMMENTS: Use additional pages if necessary to describe findings indicated in “X” and “R” check boxes. Inspected By: ____________________________________________

Job Site Rep. ___________________________________________

PR-8710-0000-0009, Rev. 03

Cranes Use and Operation吊车的使用和操作

Page 23 of 30

CSPC Nanhai Petrochemicals Project/CSPC 南海石化项目 Bechtel – SEI – Foster Wheeler PMC/项目管理承包商

ATTACHMENT D (Form 8710-0000-0009-A-Rev 02)

附件D （表8710-0000-A-02版）

PERIODIC INSPECTION FORM – RT & PEDESTAL (HYDRAULIC) 复杂地形吊车和基座式吊车（液压式）定期检查表

DATE ____________________ S/N ______________________ S/N ______________________ ODOMETER _______________

EQUIPMENT NUMBER __________________ MAKE ________________________________ ENGINE ______________________________ HOURMETER _______________________________ Previous Hr. Meter is:

(S) INSPECTED AND SATISFACTORY HYDRAULIC ASSEMBLY TOP CROWD CYLINDER BOTTOM CROWD CYL. BOOM HOIST CYL. R.R. OUTRIGGER CYL. L.R. OUTRIGGER CYL. R.F. OUTRIGGER CYL. L.F. OUTRIGGER CYL. FRONT STEERING CYL. REAR STEERING CYL. HYDRAULIC PUMP. HYD. HOIST MOTOR HYD. SWING MOTOR HYD. HOIST BRAKE HYD. SWING BRAKE HYD. FILTERS AUX. HOIST ASSEMBLY AUX. HOIST MOTOR HYDRAULIC LINES SWING LOCK PIN SWING FUNCTION MODEL ____________________ MODEL ____________________ C.P.L.#_____________________

(R) REPAIRED AND/OR ADJUSTED (X) REQUIRES RECHECK AND/OR REPAIR

S R X BOOM ASSEMBLY INNER BOOM SLIDES OUTER BOOM SLIDES POINT SHEAVES LOAD BLOCK SHEAVES HEADACHE BALL (INTL. ORANGE) LOAD BLOCK WHIP LINE CABLE LOAD CABLE S R X BODY SHEET METAL GLASS PAINT FRAME S

R

X

GENERAL ELECTRICAL BATTERY AIR SYSTEM BRAKES STEERING RING GEAR SWING PINION ENGINE PREHEATERS IJECTORS FUEL PUMP FUEL FILTER OIL FILTER HYD. FILTER AIR FILTER RADIATOR MUFFLER EX. PIPES CONVERTOR PEDESTAL ASSEMBLY OVER CENTER VALVES BOOM BOOM HOIST BOOM EXTENSION HYD. OUTRIGGERS LOAD ROPE SAFETY ITEMS LOAD CHARTS FIRE EXTINGUISHER LOAD MOMENT INDICATOR ANTI-TWO BLOCK HAND SIGNAL CHECK WARNING SIGNALS HORN BACKUP ALARM BOOM: ____________________ JIB: _______________________ DRIVE TRAIN RING REAR FRONT PINION GEAR FRONT PINION OIL SEAL L. FRONT AXLE R. FRONT AXLE FOUR-WHEEL DRIVE RING GEAR REAR PINION GEAR REAR L. REAR AXLE R. REAR AXLE TRANSMISSION HI/LO RANGE TRANS. CONVERTOR PINION OIL SEAL LUBRICATION CHECK ENGINE CHASSIS DRIVE TRAIN BOOM ASSEMBLY OUTRIGGER ASSEMBLY RING GEAR BOOM PINS LINKAGE MANUALS PARTS MANUAL SERVICE MANUAL S.L.I. MANUAL OPER. HANDBOOK ENGINE MANUAL TRIES SIZE________________________________ PLY___________________________________ TYPE____________________________________

PERCENTAGE LEFT

FRONT

Comments:

Use additional pages if necessary to describe findings indicated in “X” and “R” check boxes.

BSF Rep.: ____________________________________________ Contractor ___________________________________________

PR-8710-0000-0009, Rev. 03

Cranes Use and Operation吊车的使用和操作

Page 24 of 30